AK-107

Alexandrov/Kalashnikov 107 The 5.45 mm AK-107 with under-slung GP-30 grenade launcher. Type Assault rifle Country of Origin Russia Specifications Length 943 mm (37.1 in) stock extended 700 mm (27.6 in) stock folded Barrel 415 mm (16.3 in) Weight 3.45 kg (7.61 lb) Cartridge 5.45x39mm (AK-107) 5.56x45mm NATO (AK-108) action Gas-operated, rotating bolt, BARS system Rate of fire 850 rounds/min (AK-107) 900 rounds/min (AK-108) Muzzle velocity 900 m/s (2,953 ft/s) (AK-107) 910 m/s (2,985.6 ft/s) Feed 30-round detachable box magazine Sights Protected front post, rear U-notch on tangent Production History Designer Youriy K. Alexandrov Designed 1990s Manufacturer Izhmash Variants AK-108

The AK-107 is a Russian 5.45 mm assault rifle developed from the AK-100-series and features a "balanced" operating system, similar to that used in the AEK-971. In this case, the designation AK does not indicate Avtomat Kalashnikova but Alexandrov/Kalashnikov. The revised designation indicates the incorporation of a new gas system, designed by Youriy Alexandrov, for Kalashnikov-pattern rifles.

These new rifles were derived from the AL-7 experimental rifle of the early 1970s. The AL-7 utilized an innovative balanced gas operating system known as the Balanced Automatics Recoil System (BARS) developed by Peter Andreevich Tkachev of TsNIITochMash that was first used earlier on the AO-38 assault rifle of 1965 that essentially eliminated felt recoil and muzzle rise. The system was modified by Alexandrov, then a junior engineer at Izhmash, and prototypes were produced under the designation AL-7. The AL-7 was considered too expensive for production at the time and the Soviet Army selected the AK-74 instead as the new service rifle. No further development occurred until the mid-1990s when Alexandrov, by then a senior engineer, was directed to update his design for production as a less expensive alternative to the AN-94. The new rifle differs only slightly from the original AL-7. The AK-107 receiver is not fluted and a three-round burst feature has been added. There is otherwise little difference between it and the AL-7 prototypes.

Design details

The Balanced Automatics Recoil System, with dual counter-moving gas pistons above the barrel.

The AK-107 and AK-108 represent a significant change to the Kalashnikov operating system originally designed in the late 1940s. The new rifle features a balanced system that functions along the lines of Newton's third law of motion, which states that for every action there is an equal and opposite reaction. This system uses a recoil-dampening countermass mechanism with two operating rods that move in opposite directions, thereby providing "balance". One operating rod, the upper, has a gas piston facing forward while the bolt carrier also has a gas piston. The gas tube at the forward end of the handguard is double-ended to accommodate the two rods. The enlarged gas tube cover of the upper handguard guides both rods in their travel.

When the rifle is fired, gas is tapped from the gas port to enter the gas tube, driving the bolt carrier to the rear and the counter-recoil upper rail forward. The critical timing of the reciprocating parts is accomplished by a star-shaped sprocket that links and synchronizes both components, causing both to reach their maximum extension, or null point where forces are exactly equal, at exactly the same instant. The felt recoil is therefore eliminated, enhancing accuracy and assisting control during fully automatic fire. The travel distance of the AK-107 reciprocating parts is less than other Kalashnikov designs, so the cyclic rate is higher at 850–900 rounds/min rather than 600 rounds/min on other AK rifles. However, as the felt recoil is virtually eliminated, the manufacturer claims that accuracy is enhanced, especially during burst fire. An enhancement of 1.5 to 2 times has been reported.

The AK-107 is a selective fire weapon, with a three-round burst capability in addition to semi-automatic and fully-automatic firing modes. The system on the AK-107 resets to three-round burst each time the trigger is released, even if only one or two rounds were fired. External differences between the AK-107 and its predecessors are minor. They include a modified ejection port and a much thicker operating rod cover. The method of attaching the receiver cover now involves a rotating latch in place of the traditional Kalashnikov button at the rear of the receiver cover. The rear sight is also attached directly to the receiver cover rather than to the receiver itself and the selector has four positions instead of three. Optical and night sights can be installed, the rifle can also accept a 40 mm GP-25 grenade launcher.

The AK-108 is a version of the AK-107 chambered in 5.56x45mm NATO. Like the rest of the AK-100 series, these newer AKs use synthetic materials such as black fiberglass-reinforced polymer for the pistol grip and heat shield. This material is more cost efficient and much stronger than the original AKM/AK-74 wood furniture.

Resources

This article or section is missing resources, such as diagrams or manual links, and could use more input to fill in the missing bits. You (yes, you!) can help Gunsopedia provide more comprehensive information to our users by using your own knowledge to add to it.

See also

• AEK-971
• AO-38
• AL-7

External links

• Valery Shilin's Gun Club – Genesis of the AK-107 and AK-108 assault rifles